Trojan Boat Forum

Yes we can help we stock ever part for the Onan MCCK
Be advised lots of knock off fuel pumps from China.

Beacon Marine
609 713 4602

When the Onan 6.5 MCCK will only run when the start switch is depressed the problem is a bad rectifier bridge or main fix resister. The Onan 6.5 only uses its battery when in start mode. When the Onan 6.5 starts it generates its own voltage. Here are pictures of the two parts mentioned. We stock all...

Sounds like a ignition problem

Cap
Rotor
Wires
Ballast resister

Feel free to call
Beacon Marine
609 713 4602

A block off plate is only used between the manifold and riser or after the donut on a closed system. Three hole or one hole can be used on both sides of donut. A open system has No antifreeze, No Exchanger. Open system uses raw water to cool the block and all exhaust parts The one hole is to keep th...

The official Trojan performance number for the Crusader 270 was wide open throttle on plane 4300 RPMs, 35 MPH

You can check your tachs accuracy with a digital tach

Props should be 16 x 16 super cup Nibral

F-26 forward plexie gas’s window replacement. You can remove the plexie glass and have a sign shop make you new pieces. Try and save the trunk gasket which is the rubber gasket around the out side of windows. Best to remove the aluminum frame and take it home to work on it. The plexie glass is secur...

Hynautics steering To bleed system fill reservoir with Sea Star steering fluid. Do not use ATF Follow direction above and losses purging screws. Pump up reservoir to 35 pounds. Turn wheel 60 times to port and then 60 times to starboard. Close purging screws Check Should be hard over to hard over 5 o...

Graham D. Cardiza posted this current information about the one and only Trojan International 15 meter express on both the Trojan Facebook pages. “ Back in 2017, I was given a lead as to the whereabouts of the infamous 1 of 1, 15 Meter Trojan! Built sometime in 1984/85. It was sold to the first owne...

Chrysler Oil pan baffle When the development of the Chrysler 360 began the engineers discovered that with the longer stroke of the 360 that a oil wedge was developing in the oil pan which was dragging back the crank shaft the reducing the HP as much as 100 Hp when engine RPMs were over 3200 RPMs. ( ...

When you have tried new impeller, thermostat risers, elbows, thru hull clogged, exchanger and still can’t find the reason for the engine overheating check your hoses for a collapsed hose. Also here is the Crusader cooling test check. Closed system 10 to 15 degrees higher then water going into exchan...

Blue Print of a Trojan Cradle

Bob
Trojanboats.net

If you can find the hull number on inside of transom tamped into wood. Or possibly inside you registration number on Tile the first two letters would be one of these.

Beacon Marine
609 713 4602

Give us a call
609 713 4602
Beacon Marine

If you need an impeller for any of these pumps we have them.
Beacon Marine 609 713 4602