Engine Circuit Breaker

This forum is for comments and the exchange of information relating to Trojan Boats and boating. Please do not post used parts or boats For Sale in this area. For general, non-boating topics please use our "General Discussions" section.

Note: Negative or inflammatory postings will not be tolerated.

Moderators: BeaconMarineBob, Moderator, BeaconMarineDon

User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Engine Circuit Breaker

Post by The Dog House »

Last night some a-hole tried to steal my boat. When they were trying to hot wire it, they fried the 40 amp circuit breaker on the engine. Does anyone have any recommendations where I can get a replacement circuit breaker? The engine is a Chrysler 318 and it is the circuit breaker located above the starter motor that feeds the instrument panel. You can see it at the back left of the picture below:

Image

Thanks for any help you can provide in finding a replacement circuit breaker.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
User avatar
prowlersfish
2024 Gold Support
2024 Gold Support
Posts: 12645
Joined: Sat Nov 05, 2005 6:56 pm
Location: Lower Chesapeake Bay ,Va

Re: Engine Circuit Breaker

Post by prowlersfish »

It looks a lot like a mercruser breaker . If its not the same I would thing it could be made to work
Boating is good for the soul
77/78 TROJAN F36 Conv.
6BTA Cummins diesels
Life is to short for a ugly boat :D
User avatar
prowlersfish
2024 Gold Support
2024 Gold Support
Posts: 12645
Joined: Sat Nov 05, 2005 6:56 pm
Location: Lower Chesapeake Bay ,Va

Re: Engine Circuit Breaker

Post by prowlersfish »

Boating is good for the soul
77/78 TROJAN F36 Conv.
6BTA Cummins diesels
Life is to short for a ugly boat :D
larryeddington
2024 Gold Support
2024 Gold Support
Posts: 1870
Joined: Mon Sep 28, 2009 5:08 pm
Location: Canton, TX Boat on TEXOMA

Re: Engine Circuit Breaker

Post by larryeddington »

did they fry the whole control tower components or just the 40 CB. I have a dead 318 complete assembly. Will give you the CB or the whole tower if you want. :)
Larry Eddington
1984 F-36 Tri Cabin "The Phoenix II"
1978 F-28 "The Phoenix"
Fish Master 2350 Bay Boat
9.5' Dink
User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Re: Engine Circuit Breaker

Post by The Dog House »

larryeddington wrote:did they fry the whole control tower components or just the 40 CB. I have a dead 318 complete assembly. Will give you the CB or the whole tower if you want. :)
I'm not sure about the rest of the control tower. As of now, there is no electricity to the instrument panel. When I bypass the circuit breaker, the instrument panel has power so the circuit breaker is definitely fried. I ordered a new circuit breaker. It should be here on Wednesday. Can you put the whole tower on "hold" for me until I install the new circuit breaker? I should be able to tell you by the end of the week if installing the new circuit breaker fixes the problem or if the other components were fried also. If the other components were also fried I'd like to take you up on your offer (I'll pay for shipping, etc.). I really appreciate the offer. The generosity of the members on this forum always amazes me.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Re: Engine Circuit Breaker

Post by The Dog House »

I replaced the circuit breaker last night and the engine seems to be running fine. I'm going to take it out on a shakedown cruise this Saturday. The Klixon CDM-40 ignition protected circuit breaker was an exact match to the OEM part in case anyone ever needs to replace this part.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
DoorCountyScott
Registered user
Posts: 32
Joined: Mon May 11, 2015 12:42 pm

Re: Engine Circuit Breaker

Post by DoorCountyScott »

That sucks! Where are your key ignition? I just have ignition switches????
User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Re: Engine Circuit Breaker

Post by The Dog House »

DoorCountyScott wrote:That sucks! Where are your key ignition? I just have ignition switches????
My key ignition switch is next to my gauges. You can see it in this picture (it has the blue tape on it).

Image

You can also see the padlock and door lock I had on the cabin door. The padlock held but they were able to pull the screws holding the hasp out of the wood to free the top door. The door lock cam bent after they placed enough force on it allowing entry into the cabin. This allowed them to turn on the battery switch and try to hot wire the ignition.

I now have two hasps with larger padlocks on the door. Previously I cut the screws off flush with the wood. This time, I left the screws protrude and used steel impregnated epoxy paste to form a 2 inch diameter disk over the screws. In order for the hasp to be pulled out it will be necessary to pull that disk through the wood. I don't think that is going to happen. I also reinforced the security of the lower door, but it's not apparent and I don't want to tip my hand about what it is on a public forum. Let's just say that it is no longer possible to open the lower door by simply applying force to it.

If I can keep any potential thieves out of the cabin I can prevent them from hot wiring my boat. There is no electricity at the instrument panel until the battery switch is turned on. Let's hope my improvements in cabin security prevent this from happening again.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
DoorCountyScott
Registered user
Posts: 32
Joined: Mon May 11, 2015 12:42 pm

Re: Engine Circuit Breaker

Post by DoorCountyScott »

I lock my cabin but still have the fly bridge on my F32. Mmmm
User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Re: Engine Circuit Breaker

Post by The Dog House »

DoorCountyScott wrote:I lock my cabin but still have the fly bridge on my F32. Mmmm
Make sure you always turn your battery switch to off (I'm assuming the battery switch is located in the cabin). This way the flybridge can not be used to hot wire your boat. Your bilge pumps should be wired directly to your battery, so having the battery switch turned off should not affect them.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
User avatar
prowlersfish
2024 Gold Support
2024 Gold Support
Posts: 12645
Joined: Sat Nov 05, 2005 6:56 pm
Location: Lower Chesapeake Bay ,Va

Re: Engine Circuit Breaker

Post by prowlersfish »

Its a shame you have to do that .
Boating is good for the soul
77/78 TROJAN F36 Conv.
6BTA Cummins diesels
Life is to short for a ugly boat :D
User avatar
gordd
Sporadic User
Posts: 121
Joined: Sun Sep 02, 2012 9:24 am
Location: Mississauga ontario
Contact:

Re: Engine Circuit Breaker

Post by gordd »

Sorry to hear The Dog house . Hope no repeats of it. People can be such idiots sometime
User avatar
The Dog House
Active User
Posts: 807
Joined: Mon Jan 09, 2012 6:51 am
Location: Bordentown, NJ

Re: Engine Circuit Breaker

Post by The Dog House »

gordd wrote:Sorry to hear The Dog house . Hope no repeats of it. People can be such idiots sometime
Thanks. The police detective said he got some really good fingerprints off of the boat, so hopefully they'll catch this guy and we won't have to worry about repeats. Time will tell.
1993 Sea Ray 200 Overnighter OB with 1993 Mercury 150 hp Outboard
1979 Starcraft 14' Rowboat with 2011 Mercury 9.9 hp Outboard
Former boat: 1971 Trojan F26
User avatar
aaronbocknek
Ultimate User
Posts: 2080
Joined: Fri Sep 12, 2008 8:19 am
Location: baltimore, md (alexandria, va and middle river,md) PARKSIDE MARINA

Re: Engine Circuit Breaker

Post by aaronbocknek »

wow.........i hope they catch the thugs. a**hats!!
1982 F-36 TRI CABIN ENTERPRISE
PARKSIDE MARINA IN MIDDLE RIVER, MD
aaronbocknek@gmail.com
larryeddington
2024 Gold Support
2024 Gold Support
Posts: 1870
Joined: Mon Sep 28, 2009 5:08 pm
Location: Canton, TX Boat on TEXOMA

Re: Engine Circuit Breaker

Post by larryeddington »

Being a retired 32 year Dallas Cop, these guys are not idiots, yes stupid as working is easier. They are simply thieves, just simply lowlife, scumbum thieves. If you make it too hard to get in they will tear the whole door off. :twisted:
Larry Eddington
1984 F-36 Tri Cabin "The Phoenix II"
1978 F-28 "The Phoenix"
Fish Master 2350 Bay Boat
9.5' Dink
Post Reply